101433-9450 ZEXEL INJECTION-PUMP ASSEMBLY Cross 1014339450 16700v1302


 

Information injection-pump assembly

ZEXEL 101433-9450 1014339450
NISSAN-DIESEL 16700V1302 16700v1302
101433-9450 INJECTION-PUMP ASSEMBLY
Rating:
32
Buy INJECTION-PUMP ASSEMBLY 101433-9450 zexel genuine, new aftermarket engine parts with delivery

Cross reference number

Zexel num
Bosch num
Firm num
Name
101433-9450 
101433-9710 
 
16700V1302  NISSAN-DIESEL
INJECTION-PUMP ASSEMBLY
SD22 * K




Information:

The troubleshooting chart provides a definite sequence to be followed for a logical procedure to determine the frequency and amplitude of vibration so that the source of the vibration can be located and corrected.1. The customer must be asked questions to determine whether his complaint is valid, or whether his diagnosis of the actual problem is correct.Some of the questions that must be asked are as follows:a. What components are vibrating?b. In what speed range does this vibration become excessive?c. Does clutch operation affect the vibration?d. What is the history of the problem?2. Run the engine through the idle speed range and note all vibrating components. Look for any loose or broken mounts, brackets, and fasteners. Repair and tighten any fixtures.3. Check idle speed range with clutch disengaged. If vibrations subside, there is a balance problem with the clutch disc. The clutch disc must be repaired or replaced.4. Further analysis requires the use of a vibration instrument. Any instrument which can accurately measure the displacement of the vibration (usually in mils-inch/1000) and the frequency (cycles per second) will be sufficient. A vibration instrument such as the IRD Mechanalysis Model 320 or an equivalent instrument can be used to analyze vibration.5. Measure vibration of cab components which have the objectionable vibration.Run engine slowly through the speed range and measure vibration with the instrument filter OUT. When peak amplitudes are found, run the engine at the speeds they occur and with the instrument filter IN, find the frequency of the vibration.If the frequency of vibration is 1/2 times of engine rpm (1/2 order), the vibration is caused by a cylinder misfiring. This must be corrected before further vibration analysis is made.If the frequency of vibration is 3 times engine rpm, no corrective action can be taken on the engine because this is the firing frequency of the 3306 engine. The problem is in the cab or chassis resonance.If frequency is some order other than 1/2 or 3rd, then further measurements must be made on the engine.6. Measurements taken on the engine must be made perpendicular to the crankshaft at the front and, rear of the engine in vertical and horizontal directions.7. Record all vibrations over 4.0 mils and the engine rpm at which it occurs (100 rpm intervals are sufficient) with instrument filter OUT. Note any sudden increase and decrease in amplitudes. These occur in resonant speed ranges.If no amplitudes exceed 4.0 mils, the engine is within Caterpillar Specifications.If amplitudes exceed 4.0 mils, the vibrations must be measured with the instrument filter IN to obtain the frequency of the vibrations.8. Run the engine at high idle. With the instrument filter IN, check the frequency range and record any amplitudes over 4.0 mils and the corresponding frequency. Analysis of vibrations for the possible causes is done by identifying the frequency of the vibration and where on the engine it is the greatest magnitude. Make reference to Special Instruction, Troubleshooting Engine Vibration In Vehicular Equipment, SEHS7914 for additional information for troubleshooting vibration complaints.

Have questions with 101433-9450?





Group cross 101433-9450 ZEXEL

Nissan-Diesel 

9 400 610 033 
1670034W00 
INJECTION-PUMP ASSEMBLY
SD22
 
1670034W01 
INJECTION-PUMP ASSEMBLY
SD22
9 400 610 034 
1670034W02 
INJECTION-PUMP ASSEMBLY
SD22
9 400 614 125 
16700V1301 
INJECTION-PUMP ASSEMBLY
SD22
 
1670036W02 
INJECTION-PUMP ASSEMBLY
SD22
 
1670036W03 
INJECTION-PUMP ASSEMBLY
SD22
101433-9450  

101433-9710 
 
16700V1302 
INJECTION-PUMP ASSEMBLY
SD22
 
1679090075 
INJECTION-PUMP ASSEMBLY
SD2204
 
1670034W03 
INJECTION-PUMP ASSEMBLY
SD22
 
16700V1303 
INJECTION-PUMP ASSEMBLY
SD22
 
1670034W04 
INJECTION-PUMP ASSEMBLY
SD22
Back to top